Introduzione

This repair guide shows how to replace and clean out the fan.

Parti

Nessuna parte richiesta.

Turn the laptop upside down The battery is located on the front right side of the laptop; the opposite side from the floppy disk drive.
  • Turn the laptop upside down

  • The battery is located on the front right side of the laptop; the opposite side from the floppy disk drive.

Aggiungi Commento

As shown by the arrow, slide the plastic cover up and then pull out and downwards. You should now be able to pull the battery out. You should now be able to pull the battery out.
  • As shown by the arrow, slide the plastic cover up and then pull out and downwards.

  • You should now be able to pull the battery out.

Aggiungi Commento

Remove the four 16mm Phillips screws bordering the edge of the laptop, indicated here.
  • Remove the four 16mm Phillips screws bordering the edge of the laptop, indicated here.

Aggiungi Commento

Remove the 4mm Phillips screw on the right rear side of the laptop next to the audio ports. This will release the speaker grille.
  • Remove the 4mm Phillips screw on the right rear side of the laptop next to the audio ports.

  • This will release the speaker grille.

Aggiungi Commento

Flip the computer back over and open the screen.
  • Flip the computer back over and open the screen.

Aggiungi Commento

Slide the blue speaker grille (located above the keyboard) to the right and gently pull upward.  The grille will still be connected by a white electrical strip. Carefully pull out the white electrical strip. Carefully pull out the white electrical strip.
  • Slide the blue speaker grille (located above the keyboard) to the right and gently pull upward. The grille will still be connected by a white electrical strip.

  • Carefully pull out the white electrical strip.

Aggiungi Commento

Remove the 4mm Phillips screw in the center (located to the left of the green strip). Carefully pull the green strip straight up to disconnect it. The keyboard can now be removed.
  • Remove the 4mm Phillips screw in the center (located to the left of the green strip).

  • Carefully pull the green strip straight up to disconnect it.

  • The keyboard can now be removed.

Aggiungi Commento

Remove the four 4mm Phillips screws around the hard drive. WARNING: DVD drive is now loose as well Carefully lift the hard drive cage out.
  • Remove the four 4mm Phillips screws around the hard drive.

  • WARNING: DVD drive is now loose as well

  • Carefully lift the hard drive cage out.

  • Carefully disconnect the copper strip to pull out the hard drive.

Aggiungi Commento

With the hard drive removed, unscrew the four 6mm brass colored, Phillips screws under the hard drive cage. This will allow you to remove the hard drive mounting bracket.
  • With the hard drive removed, unscrew the four 6mm brass colored, Phillips screws under the hard drive cage.

  • This will allow you to remove the hard drive mounting bracket.

Aggiungi Commento

Remove the three 6mm brass colored, Phillips screws that hold the fan cage in place.
  • Remove the three 6mm brass colored, Phillips screws that hold the fan cage in place.

Aggiungi Commento

Remove the two 4mm black, Phillips screws shown here. Remove the 18mm silver, Phillips screw shown here.
  • Remove the two 4mm black, Phillips screws shown here.

  • Remove the 18mm silver, Phillips screw shown here.

  • Now remove the silver tab.

Aggiungi Commento

Remove the blue and red fan power cords. Remove the blue and red fan power cords.
  • Remove the blue and red fan power cords.

Aggiungi Commento

Carefully pull up and out on the metal heat sink and fan bracket. The fan can now be cleaned or replaced.
  • Carefully pull up and out on the metal heat sink and fan bracket.

  • The fan can now be cleaned or replaced.

Aggiungi Commento

Conclusione

To reassemble your device, follow these instructions in reverse order.

Un'altra persona ha completato questa guida.

Sara Lillard

Membro da: 11/04/2011

93 Reputazione

8 Guide realizzate

Team

Cal Poly, Team 12-36, Maness Spring 2011 Membro di Cal Poly, Team 12-36, Maness Spring 2011

CPSU-MANESS-S11S12G36

4 Membri

8 Guide realizzate

Aggiungi Commento

Visualizza Statistiche:

Ultime 24 Ore: 0

Ultimi 7 Giorni: 1

Ultimi 30 Giorni: 3

Tutti i Tempi: 2,168